#1
IP: 76.97.169.94
|
||||
|
||||
Tank installed now fuel pump leaks
After installing the fuel tank and running the Atomic 4 for about 30 minutes, I smelled gas in the cabin. I checked all the newly installed hoses and fittings and all were dry and tight. I then felt below the mechanical fuel pump and it was damp - with fuel. I am suspecting the fuel pump needs to come off and be replaced or rebuilt. I read the posts about the fuel pump but must admit I am not highly mechanically inclined. Is disassembly overly complex like a carburetor? Is there a way to convert it to an electrical pump and if so, are there any benefits of one over the other?
________ TV Forum Last edited by SailingAlien; 01-21-2011 at 11:52 PM. |
#2
IP: 199.246.2.10
|
|||
|
|||
Check that the sediment bowl gasget is seated correctly, I have had this problem before.
john |
#3
IP: 210.229.158.32
|
||||
|
||||
Here We Go...
Quote:
Seriously, there are PRO'S and CON'S to both pumps and they have been discussed previously. Here's an example of the discussion... http://www.moyermarine.com/forums/sh...cal+Electrical Changing to an Electric Pump is easy and I'm sure you could handle the task. If you buy the pump from MMI, they have very detailed, easy instructions. I'll let the Mechanical Pump boyz chime in as to the rebuild, but I'm willing to bet it's also within your skill level.
__________________
-Jerry 'Lone Ranger' 1978 RANGER 30 |
#4
IP: 173.166.26.241
|
||||
|
||||
I have been using an electric pump for about 18 years now and find it to be best for my application. Typically I run the engine all day in places where halts and breakdowns can be most inconvenient. I can change my fuel pump in less than 5 minutes with minimal tools. Also with a fuel tank mounted slightly higher than the engine I can limp along at minimal speed for a time. This feature would not be available with the mechanical pump. I do recognize that the mechanical pump is a proven performer thru the years, requires no electric connection or safety switch. I do remain uneasy about the possibility of a fuel leak into the crankcase. The two Carter pumps that I alternate in use are 18 years old, a little rusty on the outside, but seem unwilling to give out and make me try something else. I do usually carry a mechanical pump (and rod of course) in case another boater may need one along the way.
Last edited by hanleyclifford; 07-13-2016 at 08:36 PM. |
#5
IP: 76.97.169.94
|
||||
|
||||
Thanks y'all. Guess I'm taking the tools back to the boat to take off the fuel tank. If it is anything like my old Gran Torino taking it off shouldn't be too bad. Of course, it's in a very inconvenient place.
________ Honda GL1200SEI Last edited by SailingAlien; 01-21-2011 at 11:52 PM. |
#6
IP: 76.97.169.94
|
||||
|
||||
I found the problem but I don't know anything about the pumps condition or age so I am considering just replacing the whole unit. I did find that pulling the hand primer caused fuel to seep out the top of the unit above the fuel bowl. I couldn't find the exact location of the leak because of the location of the pump. I am having to remove it by feel as I can only see the top of the pump.
________ hotels in mexico city Last edited by SailingAlien; 01-21-2011 at 11:53 PM. |
Tags |
fuel pump, fuel system |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Experience Cleaning a Dirty Fuel Tank in Place | BobA | Fuel System | 16 | 09-21-2012 09:02 AM |
Fuel-Related Engine Shutdowns | Don Moyer | Fuel System | 32 | 02-18-2011 04:36 PM |
How much fuel should a fuel pump pump if a fuel pump does pump fuel? | Baltimore Sailor | Fuel System | 6 | 12-02-2009 09:22 PM |
Fuel Pump ID? '79 Catalina 30 | NorfolkRagbagger | Fuel System | 5 | 08-24-2009 03:41 PM |
Facet fuel pump notes | rigspelt | Fuel System | 3 | 01-03-2009 01:31 PM |