Return to the home page...

Go Back   Moyer Marine Atomic 4 Community - Home of the Afourians > Discussion Topics > General Interest

Reply
 
Thread Tools Display Modes
  #1   IP: 174.83.169.166
Old 05-09-2019, 07:43 PM
mtnsail mtnsail is offline
New Member
 
Join Date: May 2019
Posts: 1
Thanks: 0
Thanked 0 Times in 0 Posts
Engine Dies

1982 Catalina 27 with Atomic 4. when engine is first started and at idle in slip engine suddenly dies( no starving for gas) and quickly restarts. It did this twice in a couple minutes. Quickly restarted again ran for a few more minutes no problem. I then put in gear in slip and rain for another 5 minutes with no problem. ideas to trouble shoot would be appreciated
Reply With Quote
  #2   IP: 174.218.149.137
Old 05-10-2019, 07:46 AM
edwardc's Avatar
edwardc edwardc is online now
Afourian MVP
 
Join Date: Aug 2009
Location: Laurel, MD
Posts: 2,142
Thanks: 49
Thanked 238 Times in 166 Posts
Even though it shuts off abruptly, I would check the fuel pump pressure. It sounds like it can't keep up and runs the float bowl dry. Then refills it when you try to start.

I've seen this happen with the Facet electric pumps when they have the "stuck ball" problem.
__________________
@(^.^)@ Ed
1977 Pearson P-323 "Dolce Vita"
with rebuilt Atomic-4

Reply With Quote
  #3   IP: 24.152.132.140
Old 05-10-2019, 08:15 AM
ndutton's Avatar
ndutton ndutton is offline
Afourian MVP
 
Join Date: May 2009
Location: Torrance, CA
Posts: 8,433
Thanks: 132
Thanked 1,168 Times in 781 Posts
The instant restart points me away from a fuel problem. I would perform an ignition hot wire test (alligator clip jumper wire between the small coil + post and battery +) to determine an intermittent (loose) connection in the ignition circuit. Treat the jumper like an ignition switch, do not leave it connected without the engine running or else you risk permanent coil damage.

Catalina's trailer plugs in the engine harness are a known problem.
Attached Images
 
__________________
Neil
1977 Catalina 30
San Pedro, California
prior boats 1987 Westsail 32, 1970 Catalina 22
Had my hands in a few others
Reply With Quote
  #4   IP: 70.185.132.167
Old 05-10-2019, 10:24 AM
JOHN COOKSON JOHN COOKSON is online now
Afourian MVP
 
Join Date: Nov 2008
Posts: 3,036
Thanks: 35
Thanked 504 Times in 388 Posts
On my A4 there is a wire that runs from the fuel pump to the starter. This wire supplies power to the fuel pump while the engine is being cranked. The insulation had worn off the wire where it turned the corner back by the distributor. This resulted in an intermittent short at this point. Sometimes the cut outs seemed fuel related and sometimes they seemed ignition related. Kept me guessing for many months. So, have look at this wire to see if it is responsible for your cut outs.

TRUE GRIT
Reply With Quote
  #5   IP: 97.93.70.7
Old 05-10-2019, 10:42 AM
Dave Neptune Dave Neptune is online now
Afourian MVP
 
Join Date: Jan 2007
Location: Lake Arrowhead Ca.
Posts: 3,914
Thanks: 386
Thanked 321 Times in 225 Posts
more info

mtmsail, what you are describing could just be a cold start. Since it died in neutral after starting was the choke used to restart? Since it ran in gear I doubt the fuel pump. A cheap pressure gage will answer a lot of fuel issues with just a peak at the gage.

A bit more info like did you notice anything the last couple of times out?

Did you check for spark? Those plugs Neil showed are ripe for disaster at this age and not a big deal to eliminate which is god idea either way you look at it.

An engine dying when cold is not real uncommon until it has warmed for a couple of minutes. I would first try turning the IDLE AIR SCREW "IN" a half turn and then try the cold start after preparing a way to quickly check spark and/or power at the coil when/if it dies. This would be a check for the plug. Also when the engine is running wiggle and twist the plug, if she dies then BINGO there will be wiring in your future.

Dave Neptune
Reply With Quote
  #6   IP: 222.165.249.162
Old 05-10-2019, 06:55 PM
roadnsky's Avatar
roadnsky roadnsky is online now
Afourian MVP
 
Join Date: Dec 2008
Location: Boulder City, NV
Posts: 2,787
Thanks: 14
Thanked 188 Times in 138 Posts
The guys have already given you some excellent advice and pointed you to some procedures for testing.

Attached are some written step-by-step procedures from Don to add to your arsenal...
Attached Images
File Type: pdf Intermittent Shutdowns.pdf (62.2 KB, 16 views)
File Type: pdf Troubleshooting lack of spark.pdf (13.0 KB, 10 views)
File Type: pdf Troubleshooting lack of fuel.pdf (12.3 KB, 12 views)
__________________
-Jerry

'Lone Ranger'

1978 RANGER 30
Reply With Quote
The Following User Says Thank You to roadnsky For This Useful Post:
Administrator (05-10-2019)
  #7   IP: 70.185.132.167
Old 05-11-2019, 03:05 AM
JOHN COOKSON JOHN COOKSON is online now
Afourian MVP
 
Join Date: Nov 2008
Posts: 3,036
Thanks: 35
Thanked 504 Times in 388 Posts
Another Thing To Check

The OPSS can die in all sorts of weird ways. It sounds like you are running on one carburetor bowl full of gas at times then a shut down happens. Test by bypassing or shorting across the OPSS and see if the shut downs go away.

TRUE GRIT
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Engine dies then starts quickly PLUS a battery issue Jtinius Troubleshooting 1 06-16-2013 10:15 PM
Request advice with stalling engine Jon K Troubleshooting 20 09-02-2012 09:45 AM
Engine dies when it get hot chiron Troubleshooting 24 07-19-2011 12:08 AM
Engine dies every few minutes david rj Fuel System 5 09-28-2007 11:52 PM
Engine dies mwebb Troubleshooting 2 04-17-2006 06:43 PM


All times are GMT -4. The time now is 10:59 AM.


Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2019, vBulletin Solutions, Inc.


Universal® is a registered trademark of Westerbeke Corporation

Copyright © 2004-2019 Moyer Marine Inc.

All Rights Reserved