#1
IP: 24.152.132.140
|
||||
|
||||
Unexpected shutdown
I had an unexpected shutdown (aren't they ALL unexpected?) a week and a half ago. I left on a 40 mile journey (round trip) and as we departed about ¼ mile from my slip the engine faltered, faltered again and died. At the first falter my eye went immediately to the EWDS light display and stayed there through the second falter and shut down. The first parameter to alarm was the raw water flow after it quit (as it should have).
I immediately turned the ignition off for the protection of the coil and raised sail to maintain steering. With everything safe I could get down to business. What I knew thanks to the EWDS was I had sufficient fuel pressure and sufficient voltage to the coil. I thought about it for about a minute, especially my last refueling a few nights earlier. When I opened the fill plate to the main tank the O ring broke. Of course I didn't have a replacement (I do now), rain was forecast later that night and of course Catalina put the fuel fill plate right where water puddles on the deck. As a jury rig stopgap measure I wrapped teflon tape around the threads and tightened the fill cap. This episode led me to suspect the shutdown was due to water in the fuel tank. I switched the tank selector valve to my secondary tank (why doesn't everybody have a second tank?), purged the lines with my electric fuel pump via the fuel polishing switch (why doesn't everybody have that too?) and tried to restart the engine. It popped and coughed telling me there was spark. I closed the raw water intake valve to avoid overfilling the waterlift and went back to starting but feathering the choke this time. After a few more coughs she fired up. I shut her down and reopened the raw water valve, restarted her and ran maybe three ½ mile laps inside outer Los Angeles Harbor as a test run. All good. I motored over to the fuel dock, put more than enough additional fuel in the secondary tank for our planned journey and back if we had to motor the entire way and off we went. Since then I've had at least 4 hours of trouble free motoring, returned to my home slip a few days ago. My hypothesis based on all the above: probably water in the fuel but I needed to know for sure. I have since emptied 5 of the 12 gallons from the main tank, poured them into a 5 gallon drinking water bottle and inspected the contents. The attached picture tells the story. Next up I'll draw another 5 gallons from the tank and inspect again hoping to see no more water confirming that it was all drawn out with the first 5 gallons. I'll finish with the final 2 gallons as a double check. I was pleased to see no debris or other assorted nastiness in the fuel, just pure water. I rebuilt the carburetor earlier today on principle. It had enough water through it to shut the engine down so opening it up was prudent. All clean inside. Following the expected successful fuel inspections I'll replace the filter. The EWDS provided invaluable information right at the hit and saved me a ton of testing. The entire episode took maybe 5 minutes from initial failure to a running engine.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
The Following User Says Thank You to ndutton For This Useful Post: | ||
Administrator (05-13-2019) |
#2
IP: 74.107.30.201
|
||||
|
||||
good report. Sorry your s#it got jacked up..
__________________
-Shawn "Holiday" - '89 Alura 35 #109 "Twice Around" - '77 C-30, #511 with original A-4 & MMI manifold - SOLD! (no longer a two boat owner!!) |
#3
IP: 24.152.132.140
|
||||
|
||||
No worries Shawn. Thanks to the EWDS, two fuel tanks, an electric fuel pump with an override switch and the recent memory of a broken O ring right before rain it really was a minor inconvenience. At this stage we KNOW the problem was water in the fuel and we KNOW how it got in there. Now it's just the mechanics of repairing it so it never happens again.
My story was here is what happened, the information at hand, the hypothesis, the confirmation and the solution. I posted it in the hope it might help others someday.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others Last edited by ndutton; 05-12-2019 at 11:27 PM. |
The Following 3 Users Say Thank You to ndutton For This Useful Post: | ||
#4
IP: 32.211.28.40
|
||||
|
||||
The key to getting water out of the tank is to take a suction on the very bottom of the tank. The fuel pickup for the engine does NOT go to the bottom of the tank.
Access to the bottom of the tank varies from boat to boat. With my Tartan 30, I could get a piece of copper tube (about 6' long) in through the fill and to the bottom. I would then use a hand pump and pump into a gallon jug. In these days of alcohol fuels, I found comfort in doing this once a year. No need to pump the tank dry - just get the water out of the bottom. |
The Following 2 Users Say Thank You to Al Schober For This Useful Post: | ||
Administrator (08-11-2019), sastanley (05-14-2019) |
#5
IP: 73.44.129.106
|
|||
|
|||
Good idea, think I should I should add this as one more spring commissioning tasks after a 6-7 month winter layup. Pumping out a 2-3 gallons should get any residue water out of a 18 gal tank pumping from the bottom. Good to have an old monel tank. thanks
|
#6
IP: 24.152.132.140
|
||||
|
||||
I've referenced this nine year old post by Silver Fox before. The wisdom is undeniable.
http://www.moyermarineforum.com/foru...4060#post24060
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
The Following User Says Thank You to ndutton For This Useful Post: | ||
GregH (05-15-2019) |
#7
IP: 24.152.132.140
|
||||
|
||||
Second five gallons of fuel removed yesterday. Clear bottle inspection showed no water. Two gallons left to remove but that will wait until I replace the deck fill plate.
Which brings me to a decision to make: does this episode point to a fuel system modification? It's a simple fact that my cartridge style water separating fuel filter passed water right through. The previous picture showed two or more quarts of water at the bottom of five gallons of fuel that had been extracted through the filter. I hafta say, I'm not too impressed with its water separating performance. However, maybe I'm expecting more than I should. A little research found that my filter is designed to separate water emulsified in the fuel. Mine was not emulsified, it was stratified. And what is a one pint filter supposed to do with two quarts of pure water? For that matter, what is any small volume filter supposed to do with two or more quarts of pure water? Time for a rethink. I've settled on leaving the filtration as-is because:
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others Last edited by ndutton; 05-19-2019 at 11:30 AM. |
The Following User Says Thank You to ndutton For This Useful Post: | ||
BobMcD (05-21-2019) |
#9
IP: 97.93.70.7
|
|||
|
|||
Neil, about all I could think to add to your system that may be of value would be a "bottom of the tank tube" to literally pump the water/??? from under the pick up.
I actually sucked the bottom of my ski boat tank every other year. I had to do this via a syphon and always got a bit of water. This was in a boat used on the Co. River in the desert. I even removed my pick-up tube on Volador 4 or 5 times in the slip with an old "Auto pulse" pump I had set up for transferring fuel while houseboating. I also had good luck on the ski boat because I used a water separator (Fram) and then a filter/separator. Dave Neptune |
#10
IP: 24.152.132.140
|
||||
|
||||
Yeah Dave, I've been brainstorming a "better mousetrap" when it comes to fuel tank design. The current thought is to form an inverted dome, sort of a bowl shaped depression formed at the lowest point in the tank and install an extraction tube that extends to the bottom of the bowl completely separate from the fuel pickup tube.
NYV, the EWDS is an acronym for MMI's Engine Warning and Diagnostic System. The system monitors 5 separate parameters while the engine is in operation and displays a warning light and audible buzzer if any of the parameters are out of a pre-determined range specific to the Atomic 4. https://moyermarine.com/product/the-...m-ktas_01_564/ You may notice some acronyms or seemingly odd terms are underlined in the posts thusly (EWDS). Placing your pointer on the underlined term without clicking displays a brief description. As soon as my engine gave the first hint of a problem (a reduced RPM blip) my eyes went immediately to the EWDS display and stayed there throughout subsequent blips and finally shut down. No display lights illuminated until the engine stopped, then the raw water flow light illuminated first. It should have, the engine stopped, the pump stopped and the raw water was not flowing. But what did that tell me? The monitored parameters were within specification during the episode so I knew there were no issues with engine temp, oil pressure, raw water flow and most importantly, coil input voltage and fuel supply pressure to the carburetor. So what could it be? It could be loss of spark within the ignition system or a fuel issue inside the carburetor. The recent broken fuel fill O ring followed by rain pointed me in that direction so my remedial efforts were focused there.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others Last edited by ndutton; 05-19-2019 at 01:55 PM. |
#11
IP: 74.88.0.97
|
|||
|
|||
Very nice setup and write up - thanks
|
#12
IP: 24.152.132.140
|
||||
|
||||
You're welcome. If the system saves you a single tow it will have paid for itself several fold.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
The Following User Says Thank You to ndutton For This Useful Post: | ||
nyvoyager (05-19-2019) |
#13
IP: 137.103.82.194
|
||||
|
||||
Quote:
1. Refuse to pass anything at all when confronted with such a mix. 2. Pass it right on through, water and all. Racor is in the pass-it-through camp, one of my off brand filters did the opposite. I talked to a Racor engineer on the phone and he said their water separating filters were not designed for and could not deal with water and ethanol. BTW - IMHO the entire tank is ruined, there is no saving the gas. There is water and ethanol in suspension and more that separated out. |
#14
IP: 24.152.132.140
|
||||
|
||||
I concluded that I could do a better job of keeping water out of the fuel better than any filter. I think the past 14 years supports it.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
#15
IP: 137.103.82.194
|
||||
|
||||
All my water-in-fuel issues vanished when I got a new O-ring for the tank cap
|
The Following User Says Thank You to joe_db For This Useful Post: | ||
Administrator (08-11-2019) |
#16
IP: 24.152.132.140
|
||||
|
||||
Quote:
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
#17
IP: 74.88.0.97
|
|||
|
|||
Neil how much total fuel do you carry and where?
A 2nd tank is an interesting idea. Are you concerned about the additional weight? |
#18
IP: 24.152.132.140
|
||||
|
||||
Quote:
As for weight, I don't really care. I'm not a racer so an extra 1/10th of a knot is not significant to me. Besides, for Catalina trips I'm towing a 14' inflatable that costs me a full knot anyway. Hey, it's sailing. I'll get there when I get there. Good thing my slip is in the closest marina to Two Harbors at Catalina. We may not be the first to get there but we'll sure have a lot of fun on the way. Another comment on weight, just this month I made the final touch to my all chain anchor rode: painting the waterline a little higher.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others Last edited by ndutton; 05-19-2019 at 07:34 PM. |
#19
IP: 74.88.0.97
|
|||
|
|||
This may just be the thing to do with the enormous space aft of the quarter berth partition. I plan on adding an additional battery to starboard so it should roughly balance out. I'm also 25 gallons - another 50% would make a big difference!
|
#20
IP: 24.152.132.140
|
||||
|
||||
Time for an update
Well, I could have simply replaced the deck plate O ring, extracted the fuel from the tank and called it good but I think we all know I can turn something simple into a three month project. And I did.
As previously mentioned, I replaced the 42 year old factory original fuel fill deck plate with an exact match to the plate I installed with my secondary tank for uniformity of O rings and appearance. Sounds simple enough but I had built in a problem accomplishing this when I installed the secondary tank 15 years ago. The tank prevented me from crawling into the space to access the fuel fill hose clamps, under deck mounting nuts and ground wire. There is a cockpit seat hatch right there but no one has arms long enough for the necessary reach. The left picture shows the old fill plate in the center of three, the right picture shows its replacement. Out came the Sawzall and an access hole was cut in the coaming/cockpit seat back. It worked great, access was excellent. When finished I filled the hole with a coaming compartment and a matching one on the opposite side. Prior to their installation I disassembled the compartments and painted them with the same paint I used on the deck to ward off the typical UV yellowing plastics go through. Today I did the final fuel polishing through a new filter. I replaced it when done and brought it home to inspect the contents. All good.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others |
The Following 2 Users Say Thank You to ndutton For This Useful Post: | ||
Administrator (08-11-2019), thatch (08-11-2019) |
#21
IP: 76.7.131.110
|
||||
|
||||
And you tastefully included the beer pic. Cheers.
Dan S/V Marian Claire |
The Following 2 Users Say Thank You to Marian Claire For This Useful Post: | ||
Administrator (08-11-2019), GregH (08-12-2019) |
#22
IP: 24.152.132.140
|
||||
|
||||
Quote:
I should have mentioned yet again, I LOVE my electric fuel pump and bypass operation switch. It makes easy work out of transferring fuel from one tank to the other, polishing fuel through the filter, pumping a tank into jerry cans and purging the air out of a new filter cartridge. Turn a valve, flip a switch, it's that easy.
__________________
Neil 1977 Catalina 30 San Pedro, California prior boats 1987 Westsail 32, 1970 Catalina 22 Had my hands in a few others Last edited by ndutton; 08-11-2019 at 06:12 PM. |
The Following User Says Thank You to ndutton For This Useful Post: | ||
Administrator (08-11-2019) |
#23
IP: 138.207.175.60
|
||||
|
||||
Pics of the preferred beer in the image....
It's not a bug. It's a feature! Bill |
#24
IP: 72.235.8.127
|
||||
|
||||
In my business, we that an "Authenticator"
Su-weeet job Neil!
__________________
-Jerry 'Lone Ranger' 1978 RANGER 30 |
#25
IP: 157.52.12.195
|
||||
|
||||
Quick question Ndutton:
Can I assume that the cube on the port side of your wheel is the EWDS? Is that pod something you finagled or is it something you bought?
__________________
yKnot 28' Newport C&C @ PWM |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Shutdown after running for a while- coil, or is it? | cdhickey | Troubleshooting | 13 | 09-03-2018 11:32 AM |
Engine Shutdown | BlueWhale | Fuel System | 38 | 06-15-2017 09:27 PM |
Mystery Shutdown | JimPendoley | Troubleshooting | 21 | 11-19-2011 04:29 PM |
Engine gradual shutdown | ArtJ | Troubleshooting | 8 | 10-03-2011 10:14 AM |
Sudden shutdown | Maggie Anna | Ignition System | 3 | 10-10-2006 08:31 AM |